CTの取扱説明書・マニュアル [全81ページ 3.23MB]

1 .

506CT200h_U (OM76040U)4-3. Do-it-yourself maintenanceDo-it-yourself service precautionsIf you perform maintenance by yourself, be sure to follow the correct pro-cedure as given in these sections.Items Parts and tools12-volt battery condition(→P. 528)*Greas...

2 .

5074-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Items Parts and toolsEngine/power control unit coolant level (→P. 521)*"Toyota Super Long Life Coolant" or a similar high quality ethylene glycol-based non-silicate, non-amine, non-n...

3 .

5084-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Items Parts and toolsEngine oil level (→P. 517)*"Toyota Genuine Motor Oil" or equivalent*Rag or paper towel*Funnel (used only for adding engine oil)Fuses (→P. 559)*Fuse with same amperage rating as origi...

4 .

5094-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)CAUTIONThe engine compartment contains many mechanisms and fluids that may move sud-denly, become hot, or become electrically energized. To avoid death or serious injury,observe the...

5 .

5104-3. Do-it-yourself maintenanceCT200h_U (OM76040U)NOTICE■If you remove the air cleaner filterDriving with the air cleaner filter removed may cause excessive engine wear due todirt in the air. Also, a backfire could cause a fire in the engine compartment...

6 .

5114-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)HoodRelease the lock from the inside of the vehicle to open the hood.Pull the hood release lever.The hood will pop up slightly.Pull up the auxiliary catch leverand lift the hood.Hold...

7 .

5124-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■Pre-driving checkCheck that the hood is fully closed and locked. If the hood is not locked properly, it may open while the vehicle is in motion andcause an accident, which may result in death or ...

8 .

5134-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Positioning a floor jackWhen raising your vehicle with a floor jack, position the jack correctly.Improper placement may damage your vehicle or cause injury.FrontRear

9 .

5144-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■When raising your vehicleMake sure to observe the following precauti ons to reduce the possibility of death orserious injury:●When using a floor jack, follow the instructions of the manual provid...

10 .

5154-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Engine compartment■12-volt battery→P. 528Engine coolant reservoir (→P. 521 )Engine oil level dipstick (→P. 517 )Engine oil filler cap (→P. 517 )Power control unit coolantreservoir ...

11 .

5164-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Engine compartment cover■Removing the engine compartment cover■Installing the clipsPush up center portionInsertPressNOTICE■After installing an engine compartment coverMake sure that the cover is securely...

12 .

5174-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Engine oilWith the engine at operating temperat ure and turned off, check the oillevel on the dipstick.■Checking the engine oilPark the vehicle on level ground. After warming up the ...

13 .

5184-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Adding engine oilIf the oil level is below or near thelow level mark, add engine oil ofthe same type as that already in theengine.Make sure to check the oil type and prepare the items needed beforeaddin...

14 .

5194-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Engine oil consumption●The amount of engine oil consumed depe nds on the oil viscosity, the quality ofthe oil and the way the vehicle is driven.●More oil is consumed under driving c...

15 .

5204-3. Do-it-yourself maintenanceCT200h_U (OM76040U)NOTICE■To prevent serious engine damageCheck the oil level on a regular basis.■When replacing the engine oil●Be careful not to spill engine oil on the vehicle components.●Avoid overfilling, or the engine...

16 .

5214-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)CoolantThe coolant level is satisfactory if it is between the "FULL" and "LOW"lines on the reservoir when the hybrid system is cold.Engine coolant reservoirReservoir cap"FULL" line"...

17 .

5224-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Coolant selectionOnly use "Toyota Super Long Life Coolant" or a similar high quality ethylene glycolbased non-silicate, non-amine, non-nitrite, and non-borate coolant with long-lifehybrid organic acid ...

18 .

5234-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)NOTICE■When adding coolantCoolant is neither plain water nor straight antifreeze. The correct mixture of waterand antifreeze must be used to provide proper lubrication, corrosion p...

19 .

5244-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Radiator and condenserCheck the radiator and condenser an d clear away any foreign objects. If either of the above parts is extremely dirty or you are not sure of theircondition, have your vehicle inspe...

20 .

5254-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Brake fluid■Checking fluid levelThe brake fluid level should bebetween the "MAX" and "MIN"lines on the tank.■Adding fluidMake sure to check the fluid type and prepare the necessary i...

21 .

5264-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■When filling the reservoirTake care as brake fluid can harm your hands and eyes and damage painted sur-faces.If fluid gets on your hands or in your eyes, flush the affected area with clean wateri...

22 .

5274-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Washer fluidIf any washer does not work or thewarning message appears on themulti-information display, thewasher tank may be empty. Addwasher fluid.CAUTION■When adding washer fluidDo...

23 .

5284-3. Do-it-yourself maintenanceCT200h_U (OM76040U)12-volt battery■LocationThe 12-volt battery is located inthe right-hand side of luggagecompartment.■Removing the 12-volt battery coverOpen the center and right side auxiliary boxes. ( →P. 462)Remove the ...

24 .

5294-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■ExteriorMake sure that the 12-volt battery terminals are not corroded andthat there are no loose connections, cracks, or loose clamps.TerminalsHold-down clamp

25 .

5304-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Installing the 12-volt battery maintenance coverInsert the 2 tabs on the far sideof the cover into the holes.Hook on the 2 tabs on the nearside of the cover.Hook on the 2 tabs on theupper side of the co...

26 .

5314-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Before rechargingWhen recharging, the 12-volt battery produces hydrogen gas which is flammableand explosive. Therefore, observe the following precautions before recharging:●If recha...

27 .

5324-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■Chemicals in the 12-volt batteryThe 12-volt battery contains poisonous and corrosive sulfuric acid and may pro-duce hydrogen gas which is flammable and ex plosive. To reduce the risk of death ors...

28 .

5334-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)CAUTION■Emergency measures regarding electrolyte●If electrolyte gets in your eyesFlush your eyes with clean water for at least 15 minutes and get immediate medi-cal attention. If po...

29 .

5344-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■When disconnecting the 12-volt batteryNOTICE■When recharging the 12-volt batteryNever recharge the 12-volt battery while the hybrid system is operating. Also, besure all accessories are turned of...

30 .

5354-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)TiresReplace or rotate tires in accordan ce with maintenance schedules andtreadwear.■Checking tiresNew treadTreadwear indicatorWorn treadThe location of treadwear indi-cators is show...

31 .

5364-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Tire pressure warning systemYour vehicle is equipped with a tire pressure warning system thatuses tire pressure warning valves and transmitters to detect low tireinflation pressure before serious prob...

32 .

5374-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Installing tire pressure warning valves and transmittersWhen replacing tires or wheels, tire pressure warning valves and trans-mitters must also be installed.When new tire pressure w...

33 .

5384-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■How to initialize the tire pressure warning systemPark the vehicle in a safe place and turn the "POWER" switch off.Initialization cannot be performed while the vehicle is moving.Adjust the tire inflatio...

34 .

5394-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Registering ID codesThe tire pressure warning valve and transmitter is equipped with a uniqueID code. When replacing a tire pressure warning valve and transmitter, itis necessary to...

35 .

5404-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Routine tire inflation pressure checksThe tire pressure warning system does not replace routine tire inflation pressurechecks. Make sure to check tire inflation pressure as part of your routine of daily...

36 .

5414-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Tire types●Summer tiresSummer tires are high-speed performance tires best suited to highway drivingunder dry conditions. Since summer tires do not have the same traction perfor-man...

37 .

5424-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Initializing the tire pressure warning systemInitialize the system with the tire inflatio n pressure adjusted to the specified level.■If the tread on snow tires wears down below 0.16 in. (4 mm)The effec...

38 .

5434-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Tire pressure warning system certificationFor vehicles sold in the U.S.A.MODEL/FCC IDs:Transmitter: PAXPMV107JReceiver: HYQ13BDEThis device complies with Part 15 of the FCC Rules. O...

39 .

5444-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■When inspecting or replacing tiresObserve the following precautions to prevent accidents.Failure to do so may cause damage to part s of the drive train as well as dangeroushandling characteristic...

40 .

5454-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)NOTICE■Repairing or replacing tires, wheels, ti re pressure warning valves, transmittersand tire valve caps●When removing or fitting the wheels, tires or the tire pressure warning va...

41 .

5464-3. Do-it-yourself maintenanceCT200h_U (OM76040U)NOTICE■Low profile tires (vehicles with 17 inch tires)Low profile tires may cause greater damage than usual to the tire wheel when sus-taining impact from the road surface. Therefore, pay attention to th...

42 .

5474-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Tire inflation pressure■Tire inflation pressureThe recommended cold tire inflation pressure and tire size are dis-played on the tire and loading information label. ( →P. 677)

43 .

5484-3. Do-it-yourself maintenanceCT200h_U (OM76040U).■Inspection and adjustment procedureTire valveTire pressure gaugeRemove the tire valve cap.Press the tip of the tire pressure gauge onto the tire valve.Read the pressure using the gauge gradations.If th...

44 .

5494-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Tire inflation pressure check intervalYou should check tire inflation pressure every two weeks, or at least once a month.Do not forget to check the spare.■Effects of incorrect tire ...

45 .

5504-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■Proper inflation is critical to save tire performanceKeep your tires properly inflated. Otherwise, the following conditions may occurand result in an accident causing death or serious injury:●Exc...

46 .

5514-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)WheelsIf a wheel is bent, cracked or heavily corroded, it should be replaced. Oth-erwise, the tire may separate from th e wheel or cause a loss of handlingcontrol.■Wheel selectionWhe...

47 .

5524-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■When replacing wheelsThe wheels of your vehicle are equipped with tire pressure warning valves andtransmitters that allow the tire pressure warning system to provide advance warningin the event of a lo...

48 .

5534-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)NOTICE■Replacing tire pressure warning valves and transmitters●Because tire repair or replacement may affect the tire pressure warning valvesand transmitters, make sure to have tires...

49 .

5544-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Air conditioning filterThe air conditioning filter must be changed regularly to maintain air condi-tioning efficiency.■Removal methodTurn the "POWER" switch off.Open the glove box. Lift andremove the par...

50 .

5554-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Checking intervalInspect and replace the air conditioning filter according to the maintenance sched-ule. In dusty areas or areas with heavy traffic flow, early replacement may bereq...

51 .

5564-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Electronic key batteryReplace the battery with a new one if it is depleted.■You will need the following items:●Flathead screwdriver●Lithium battery CR1632■Replacing the batteryTake out the mechanical key...

52 .

5574-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Use a CR1632 lithium battery●Batteries can be purchased at your Le xus dealer, local electrical applianceshops or camera stores.●Replace only with the same or equivalent type recomm...

53 .

5584-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■Removed battery and other partsKeep away from children. These parts are small and if swallowed by a child, they cancause choking. Failure to do so coul d result in death or serious injury.NOTICE■...

54 .

5594-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Checking and replacing fusesIf any of the electrical components do not operate, a fuse may have blown.If this happens, check and re place the fuses as necessary.Turn the "POWER" swit...

55 .

5604-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Remove the fuse.Only type A fuse can beremoved using the pullout tool.Check if the fuse is blown.Type ANormal fuseBlown fuseReplace the blown fuse with anew fuse of an appropriateamperage rating. The amp...

56 .

5614-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Type CNormal fuseBlown fuseReplace the blown fuse with anew fuse of an appropriateamperage rating. The amperagerating can be found on the fusebox lid.Type DNormal fuseBlown fuseRepla...

57 .

5624-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Fuse layout and amperage ratingsEngine compartmentFuse Ampere Circuit1DC/DC 125 A Inverter and converter2HTR 50 A Air conditioning system3RDI 30 A Electric cooling fans4CDS 30 A Electric cooling fans5RAD...

58 .

5634-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)11AMP NO.2 30 A Audio system12ETCS 10 AMultiport fuel injection system/sequential multiport fuel injection sys-tem13IGCT 30 A PCU, IGCT NO.2, IGCT NO.314DC/DC-S 5 A Inverter and conv...

59 .

5644-3. Do-it-yourself maintenanceCT200h_U (OM76040U)26H-LP HI MAIN 20 A H-LP RH HI, H-LP LH HI27DRL 7.5 A Daytime running light system28DOOR NO.2 25 A Power door lock system29P/I 1 60 A IG2, EFI MAIN, BATT FAN30EPS 60 A Electric power steering system31PCU...

60 .

5654-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)38EFI NO. 2 10 AMultiport fuel injection system/sequential multiport fuel injection sys-tem, exhaust system, key off pump module, electric cooling fans39M-HTR 10 A Outside rear view ...

61 .

5664-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Left side instrument panelFuse Ampere Circuit1TAIL 10 AHeadlights (high beam), stop/tail lights, license plate lights, parking lights2PANEL 10 AAudio system, intuitive parking assist switch, windshield w...

62 .

5674-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)3IGN 10 AElectronically controlled brake sys-tem, smart access system with push-button start, multiport fuel injection system/sequential multiport fuel injec-tion system, stop/tail l...

63 .

5684-3. Do-it-yourself maintenanceCT200h_U (OM76040U)11ECU-IG NO.1 10 A No circuit12S/ROOF 30 A Moon roof13DOOR RL 25 A Power windows14DOOR RR 25 A Power windows15D FR DOOR 25 APower windows, outside rear view mirrors16P FR DOOR 25 APower windows, outside ...

64 .

5694-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)27SEAT HTR FL 10 A Seat heaters28SEAT HTR FR 10 A Seat heaters29RAD NO.2 7.5 AAudio system, navigation system, overhead module30PWR OUTLET 15 A Power outlet (center console)31ECU-ACC...

65 .

5704-3. Do-it-yourself maintenanceCT200h_U (OM76040U)CAUTION■To prevent system breakdowns and vehicle fireObserve the following precautions.Failure to do so may cause damage, and possibly a fire or injury.●Never use a fuse of a higher amperage rating than...

66 .

5714-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Light bulbsYou may replace the following bulbs by yourself. The difficulty level ofreplacement varies depending on the bulb. If necessary bulb replacementseems difficult to perform,...

67 .

5724-3. Do-it-yourself maintenanceCT200h_U (OM76040U)LED headlights■Rear bulb locationsHeadlight high beamFront turn signal light Front fog lightRear turn signal lightBack-up lightLicense plate lights

68 .

5734-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Replacing light bulbs■Headlight low beams (halogen headlights)For the right side only: Remove thesecuring clips and unclip theengine coolant reservoir hose.Then lift up the air clean...

69 .

5744-3. Do-it-yourself maintenanceCT200h_U (OM76040U)Turn the bulb base counterclock-wise.■Headlight high beams (halogen headlights)For the right side only: Move thewasher fluid filler opening.Unplug the connector while press-ing the lock release.Turn the ...

70 .

5754-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Headlight high beams (LED headlights)For the right side only: Remove th e securing clips and unclip theengine coolant reservoir hose. Th en lift up the air cleaner inletduct. (→P. 5...

71 .

5764-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Front fog lights (if equipped)Remove 2 screws, a bolt and clip,and pull down the engine undercover.Pull the cover down slowly, beingcareful not to dislodge any fixedcomponents.Unplug the connector while...

72 .

5774-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Front turn signal lights (halogen headlights)For the right side only: Remove th e securing clips and unclip theengine coolant reservoir hose. Th en lift up the air cleaner inletduct...

73 .

5784-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Front turn signal lights (LED headlights)Left sideRemove the power control unitcover.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

74 .

5794-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)Right sideMove the washer fluid filler opening. ( →P. 574)Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

75 .

5804-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■Rear turn signal lightsOpen the back door and removethe covers and bolts, and removethe lamp assembly by pulling itdirectly backward from the rear ofthe vehicle.Use a flathead screwdriverwrapped in a cl...

76 .

5814-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Back-up lightsOpen the back door and removethe cover.Use a flathead screwdriverwrapped in a cloth.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

77 .

5824-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■License plate lightsOpen the back door and removethe cover.Use a flathead screwdriverwrapped in a cloth.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

78 .

5834-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)■Lights other than the aboveIf any of the lights listed below ha s burnt out, have it replaced by yourLexus dealer.●Headlight low beams (LED type)●Parking lights and daytime running ...

79 .

5844-3. Do-it-yourself maintenanceCT200h_U (OM76040U)■After replacing the bulbs■LED lightsThe headlight low beams (LED type), parking lights, front side marker lights, day-time running lights, side turn signal lights, rear side marker lights, stop/tail l...

80 .

5854-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76040U)CAUTION■Replacing light bulbs●Turn off the lights. Do not attempt to replace the bulb immediately after turningoff the lights. The bulbs become very hot and may cause burns.●Do not t...

81 .

5864-3. Do-it-yourself maintenanceCT200h_U (OM76040U)