CTの取扱説明書・マニュアル [全80ページ 3.27MB]

1 .

4894Maintenance and careCT200h_U (OM76004U)4-3. Do-it-yourself maintenanceDo-it-yourself service precautionsIf you perform maintenance by yourself, be sure to follow the correct pro-cedure as given in these sections.Items Parts and tools12-volt battery con...

2 .

4904-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Items Parts and toolsEngine/power control unit coolant level (→P. 504)*"Toyota Super Long Life Coolant" or a similar high quality ethylene glycol-based non-silicate, non-amine, non-nitrite and non-borate...

3 .

4914-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Items Parts and toolsEngine oil level (→P. 500)*"Toyota Genuine Motor Oil" or equivalent*Rag or paper towel*Funnel (used only for adding engine oil)Fuses (→P. 542)*Fuse with same amp...

4 .

4924-3. Do-it-yourself maintenanceCT200h_U (OM76004U)CAUTIONThe engine compartment contains many mechanisms and fluids that may move sud-denly, become hot, or become electrically energized. To avoid death or serious injury, observe the following precautio...

5 .

4934-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)NOTICEnIf you remove the air cleaner filterDriving with the air cleaner filter removed may cause excessive engine wear due to dirt in the air. Also, a backfire could cause a fire in ...

6 .

4944-3. Do-it-yourself maintenanceCT200h_U (OM76004U)HoodRelease the lock from the inside of the vehicle to open the hood.Pull the hood release lever.The hood will pop up slightly.Pull up the auxiliary catch lever and lift the hood.Hold the hood open by in...

7 .

4954-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnPre-driving checkCheck that the hood is fully closed and locked. If the hood is not locked properly, it may open while the vehicle is in motion and cause an accident, which...

8 .

4964-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Positioning a floor jackWhen raising your vehicle with a floor jack, position the jack correctly. Improper placement may damage your vehicle or cause injury.FrontRear

9 .

4974-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnWhen raising your vehicleMake sure to observe the following precauti ons to reduce the possibility of death or serious injury:lWhen using a floor jack, follow the instruction...

10 .

4984-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Engine compartmentn12-volt battery→P. 511Engine coolant reservoir (→P. 504 )Engine oil level dipstick (→P. 500 )Engine oil filler cap (→P. 500 )Power control unit coolant reservoir (→P. 504 )Brake flu...

11 .

4994-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Engine compartment covernRemoving the engine compartment covernInstalling the clipsPush up center portionInsertPressNOTICEnAfter installing an engine compartment coverMake sure that ...

12 .

5004-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Engine oilWith the engine at operating temperat ure and turned off, check the oil level on the dipstick.nChecking the engine oilPark the vehicle on level ground. After turning off the hybrid sys-tem, wa...

13 .

5014-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nAdding engine oilIf the oil level is below or near the low level mark, add engine oil of the same type as that already in the engine.Make sure to check the oil type and prepare the ...

14 .

5024-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nEngine oil consumptionlThe amount of engine oil consumed depend s on the oil viscosity, the quality of the oil and the way the vehicle is driven.lMore oil is consumed under driving co nditions such as h...

15 .

5034-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnUsed engine oillUsed engine oil contains potentially harmful contaminants which may cause skin disorders such as inflammation and skin ca ncer, so care should be taken to avo...

16 .

5044-3. Do-it-yourself maintenanceCT200h_U (OM76004U)CoolantThe coolant level is satisfactory if it is between the "FULL" and "LOW" lines on the reservoir when the hybrid system is cold.Engine coolant reservoirReservoir cap"FULL" line"LOW" lineIf the leve...

17 .

5054-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nCoolant selectionOnly use "Toyota Super Long Life Coolant" or a similar high quality ethylene glycol based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-li...

18 .

5064-3. Do-it-yourself maintenanceCT200h_U (OM76004U)NOTICEnWhen adding coolantCoolant is neither plain water nor straight antifreeze. The correct mixture of water and antifreeze must be used to provide proper lubrication, corrosion protection and coolin...

19 .

5074-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Radiator and condenserCheck the radiator and condenser an d clear away any foreign objects. If either of the above parts is extremely dirty or you are not sure of their condition,...

20 .

5084-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Brake fluidnChecking fluid levelThe brake fluid level should be between the "MAX" and "MIN" lines on the tank.nAdding fluidMake sure to check the fluid type and prepare the necessary item.Fluid type FMVS...

21 .

5094-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnWhen filling the reservoirTake care as brake fluid can harm your hands and eyes and damage painted sur-faces. If fluid gets on your hands or in your eyes, flush the affected ...

22 .

5104-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Washer fluidIf any washer does not work or the warning message appears on the multi-information display, the washer tank may be empty. Add washer fluid.CAUTIONnWhen adding washer fluidDo not add washer f...

23 .

5114-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)12-volt batterynLocationThe 12-volt battery is located in the right-hand side of luggage compartment.nRemoving the 12-volt battery coverOpen the center and right side auxiliary boxes...

24 .

5124-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nExteriorMake sure that the 12-volt battery terminals are not corroded and that there are no loose connections, cracks, or loose clamps.TerminalsHold-down clamp

25 .

5134-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nInstalling the 12-volt battery maintenance coverInsert the 2 tabs on the far side of the cover into the holes.Hook on the 2 tabs on the near side of the cover.Hook on the 2 tabs on ...

26 .

5144-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nBefore rechargingWhen recharging, the 12-volt battery produces hydrogen gas which is flammable and explosive. Therefore, observe the following precautions before recharging:lIf recharging with the 12-vo...

27 .

5154-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnChemicals in the 12-volt batteryThe 12-volt battery contains poisonous and corrosive sulfuric acid and may pro-duce hydrogen gas which is flammable and explosive. To reduce t...

28 .

5164-3. Do-it-yourself maintenanceCT200h_U (OM76004U)CAUTIONnEmergency measures regarding electrolytelIf electrolyte gets in your eyes Flush your eyes with clean water for at least 15 minutes and get immediate medi-cal attention. If possible, continue to...

29 .

5174-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnWhen disconnecting the 12-volt batteryNOTICEnWhen recharging the 12-volt batteryNever recharge the 12-volt battery while the hybrid system is operating. Also, be sure all acc...

30 .

5184-3. Do-it-yourself maintenanceCT200h_U (OM76004U)TiresReplace or rotate tires in accordan ce with maintenance schedules and treadwear.nChecking tiresNew treadTreadwear indicatorWorn treadThe location of treadwear indi-cators is shown by the "TWI" or "∆...

31 .

5194-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nTire pressure warning systemYour vehicle is equipped with a ti re pressure warning system that uses tire pressure warning valves and transmitters to detect low tire inflation press...

32 .

5204-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Installing tire pressure warning valves and transmittersWhen replacing tires or wheels, tire pressure warning valves and trans-mitters must also be installed.When new tire pressure warning va lves and tr...

33 .

5214-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nHow to initialize the tire pressure warning systemPark the vehicle in a safe place and turn the "POWER" switch off.Initialization cannot be performed while the vehicle is moving.Adj...

34 .

5224-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Registering ID codesThe tire pressure warning valve and transmitter is equipped with a unique ID code. When replacing a tire pressu re warning valve and transmitter, it is necessary to register the ID c...

35 .

5234-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nRoutine tire inflation pressure checksThe tire pressure warning system does not replace routine tire inflation pressure checks. Make sure to check tire inflation pressure as part of...

36 .

5244-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nTire typeslSummer tiresSummer tires are high-speed performance tires best suited to highway driving under dry conditions. Since summer tires do not have the same traction perfor-mance as snow tires, su...

37 .

5254-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nInitializing the tire pressure warning systemInitialize the system with the tire inflatio n pressure adjusted to the specified level.nIf the tread on snow tires wears down below 0.1...

38 .

5264-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nTire pressure warning system certificationFor vehicles sold in the U.S.A.MODEL/FCC IDs:Transmitter: PAXPMV107JReceiver: HYQ13BDEThis device complies with Part 15 of the FCC Rules. Operation is subject t...

39 .

5274-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnWhen inspecting or replacing tiresObserve the following precautions to prevent accidents. Failure to do so may cause damage to parts of the drive train as well as dangerous ...

40 .

5284-3. Do-it-yourself maintenanceCT200h_U (OM76004U)NOTICEnRepairing or replacing tires, wheels, ti re pressure warning valves, transmitters and tire valve capslWhen removing or fitting the wheels, tires or the tire pressure warning valves and transmitter...

41 .

5294-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)NOTICEnLow profile tires (vehicles with 17 inch tires)Low profile tires may cause greater damage than usual to the tire wheel when sus-taining impact from the road surface. Therefore...

42 .

5304-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Tire inflation pressurenTire inflation pressureThe recommended cold tire inflation pressure and tire size are dis-played on the tire and loading information label. ( →P. 661)

43 .

5314-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U).nInspection and adjustment procedureTire valveTire pressure gaugeRemove the tire valve cap.Press the tip of the tire pressure gauge onto the tire valve.Read the pressure using the g...

44 .

5324-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nTire inflation pressure check intervalYou should check tire inflation pressure every two weeks, or at least once a month. Do not forget to check the spare.nEffects of incorrect tire inflation pressureD...

45 .

5334-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnProper inflation is critical to save tire performanceKeep your tires properly inflated. Otherw ise, the following conditions may occur and result in an accident cau sing deat...

46 .

5344-3. Do-it-yourself maintenanceCT200h_U (OM76004U)WheelsIf a wheel is bent, cracked or heavily corroded, it should be replaced. Oth-erwise, the tire may separate from th e wheel or cause a loss of handling control.nWheel selectionWhen replacing wheels, ...

47 .

5354-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nWhen replacing wheelsThe wheels of your vehicle are equipped with tire pressure warning valves and transmitters that allow the tire pressure warning system to provide advance warni...

48 .

5364-3. Do-it-yourself maintenanceCT200h_U (OM76004U)NOTICEnReplacing tire pressure warning valves and transmitterslBecause tire repair or replacement may affect the tire pressure warning valves and transmitters, make sure to have tires serviced by your Le...

49 .

5374-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Air conditioning filterThe air conditioning filter must be changed regularly to maintain air condi-tioning efficiency.nRemoval methodTurn the "POWER" switch off.Open the glove box. L...

50 .

5384-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nChecking intervalInspect and replace the air conditioning filter according to the maintenance sched-ule. In dusty areas or areas with heavy traffic flow, early replacement may be required. (For schedule...

51 .

5394-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Electronic key batteryReplace the battery with a new one if it is depleted.nYou will need the following items:lFlathead screwdriverlLithium battery CR1632nReplacing the batteryTake o...

52 .

5404-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nUse a CR1632 lithium batterylBatteries can be purchased at your Le xus dealer, local electrical appliance shops or camera stores.lReplace only with the same or equivalent type recommended by the manufac...

53 .

5414-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnRemoved battery and other partsKeep away from children. These parts are small and if swallowed by a child, they can cause choking. Failure to do so coul d result in death or ...

54 .

5424-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Checking and replacing fusesIf any of the electrical components do not operate, a fuse may have blown. If this happens, check and re place the fuses as necessary.Turn the "POWER" switch off.Open the fuse...

55 .

5434-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Remove the fuse.Only type A fuse can be removed using the pullout tool.Check if the fuse is blown.Type ANormal fuseBlown fuseReplace the blown fuse with a new fuse of an appropriate ...

56 .

5444-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Type CNormal fuseBlown fuseReplace the blown fuse with a new fuse of an appropriate amperage rating. The amperage rating can be found on the fuse box lid.Type DNormal fuseBlown fuseReplace the blown fuse...

57 .

5454-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Fuse layout and amperage ratingsEngine compartmentFuse Ampere Circuit1DC/DC 125 A Inverter and converter2HTR 50 A Air conditioning system3RDI 30 A Electric cooling fans4CDS 30 A Elec...

58 .

5464-3. Do-it-yourself maintenanceCT200h_U (OM76004U)11AMP NO.2 30 A Audio system12ETCS 10 AMultiport fuel injection system/sequential multiport fuel injection sys-tem13IGCT 30 A PCU, IGCT NO.2, IGCT NO.314DC/DC-S 5 A Inverter and converter15P CON MAIN 7.5...

59 .

5474-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)26H-LP HI MAIN 20 A H-LP RH HI, H-LP LH HI27DRL 7.5 A Daytime running light system28DOOR NO.2 25 A Power door lock system29P/I 1 60 A IG2, EFI MAIN, BATT FAN30EPS 60 A Electric power...

60 .

5484-3. Do-it-yourself maintenanceCT200h_U (OM76004U)38EFI NO. 2 10 AMultiport fuel injection system/sequential multiport fuel injection sys-tem, exhaust system, key off pump module, electric cooling fans39M-HTR 10 A Outside rear view mirror defoggers40SPA...

61 .

5494-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Left side instrument panelFuse Ampere Circuit1TAIL 10 AHeadlights (high beam), stop/tail lights, license plate lights, parking lights2PANEL 10 AAudio system, intuitive parking assist...

62 .

5504-3. Do-it-yourself maintenanceCT200h_U (OM76004U)3IGN 10 AElectronically controlled brake sys-tem, smart access system with push-button start, multiport fuel injection system/sequential multiport fuel injec-tion system, stop/tail lights, SRS air-bags4M...

63 .

5514-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)11ECU-IG NO.1 10 A No circuit12S/ROOF 30 A Moon roof13DOOR RL 25 A Power windows14DOOR RR 25 A Power windows15D FR DOOR 25 APower windows, outside rear view mirrors16P FR DOOR 25 APo...

64 .

5524-3. Do-it-yourself maintenanceCT200h_U (OM76004U)27SEAT HTR FL 10 A Seat heaters28SEAT HTR FR 10 A Seat heaters29RAD NO.2 7.5 AAudio system, navigation system, overhead module30PWR OUTLET 15 A Power outlet31ECU-ACC 10 AAir conditioning system, outside ...

65 .

5534-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)CAUTIONnTo prevent system breakdowns and vehicle fireObserve the following precautions. Failure to do so may cause damage, and possibly a fire or injury.lNever use a fuse of a highe...

66 .

5544-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Light bulbsYou may replace the following bulbs by yourself. The difficulty level of replacement varies depending on the bulb. If necessary bulb replacement seems difficult to perform, contact your Lexus...

67 .

5554-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)LED headlightsnRear bulb locationsHeadlight high beamFront turn signal light Front fog lightRear turn signal lightBack-up lightLicense plate lights

68 .

5564-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Replacing light bulbsnHeadlight low beams (halogen headlights)For the right side only: Remove the securing clips and unclip the engine coolant reservoir hose. Then lift up the air cleaner inlet duct.Unpl...

69 .

5574-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)Turn the bulb base counterclock-wise.nHeadlight high beams (halogen headlights)For the right side only: Move the washer fluid filler opening.Unplug the connector while press-ing the ...

70 .

5584-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nHeadlight high beams (LED headlights)For the right side only: Remove th e securing clips and unclip the engine coolant reservoir hose. Th en lift up the air cleaner inlet duct. (→P. 556)Turn the cover c...

71 .

5594-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nFront fog lights (if equipped)Remove 2 screws, a bolt and clip, and pull down the engine under cover.Pull the cover down slowly, being careful not to dislodge any fixed components.U...

72 .

5604-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nFront turn signal lights (halogen headlights)For the right side only: Remove th e securing clips and unclip the engine coolant reservoir hose. Th en lift up the air cleaner inlet duct. (→P. 556)Turn the...

73 .

5614-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nFront turn signal lights (LED headlights)Left sideRemove the power control unit cover.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

74 .

5624-3. Do-it-yourself maintenanceCT200h_U (OM76004U)Right sideMove the washer fluid filler opening. ( →P. 557)Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

75 .

5634-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nRear turn signal lightsOpen the back door and remove the covers and bolts, and remove the lamp assembly by pulling it directly backward from the rear of the vehicle.Use a flathead s...

76 .

5644-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nBack-up lightsOpen the back door and remove the cover.Use a flathead screwdriver wrapped in a cloth.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP 3

77 .

5654-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nLicense plate lightsOpen the back door and remove the cover.Use a flathead screwdriver wrapped in a cloth.Turn the bulb base counterclock-wise.Remove the light bulb.STEP 1STEP 2STEP...

78 .

5664-3. Do-it-yourself maintenanceCT200h_U (OM76004U)nLights other than the aboveIf any of the lights listed below ha s burnt out, have it replaced by your Lexus dealer.lHeadlight low beams (LED type)lParking lights and daytime running lightslFront side ma...

79 .

5674-3. Do-it-yourself maintenance4Maintenance and careCT200h_U (OM76004U)nAfter replacing the bulbsnLED lightsThe headlight low beams (LED type), parking lights, front side marker lights, day-time running lights, side turn signal lights, rear side marke...

80 .

5684-3. Do-it-yourself maintenanceCT200h_U (OM76004U)CAUTIONnReplacing light bulbslTurn off the lights. Do not attempt to replace the bulb immediately after turning off the lights. The bulbs become very hot and may cause burns.lDo not touch the glass port...