ダッジ・バンの取扱説明書・マニュアル [全45ページ 4.95MB]

1 .

All Dodge Models and 200 Chevrolet Owner's ManualIncluding Limited Warranty Information

2 .

WARNINGS & CAUTIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203WARNINGS AND CAUTIONSThis manual contains WARNINGSagainst operatingprocedures which could result in an accident or bodily injury.The manual also contains CAUTIONSagainst pr...

3 .

TABLE OF CONTENTSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1Introduction________________________________________________________________________________PrefaceElevations___________________________________________________________...

4 .

TABLE OF CONTENTSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1Stationary Use (Doors Open) ______________________________________________________________________F-3Range Hood Exhaust Fan_____________________________________________...

5 .

INTRODUCTION Doc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 A.0A WORD TO ROADTREK OWNERS...This manual has been prepared to acquaint you with the operation,maintenance and warranties of your newRoadtrek Motorhome Van. Your vehicle has be...

6 .

INTRODUCTIONDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203Gross Combination Weight Rating (GCWR)The Chevrolet 3500 extended van has a GCWR of 6350Kg/14000 lbs for the standard engine (6.0 L) and 7258Kg/16000 lbs for the optional 4.10 rea...

7 .

ELEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1200-POPULARELEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1200-POPULAR

8 .

200-VERSATILEELEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1200-VERSATILE

9 .

190-POPULARELEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1190-POPULAR

10 .

190-VERSATILEELEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1190-VERSATILE

11 .

ELVEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1170-POPULARELVEVATIONSDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B - 1170-POPULAR

12 .

CAPTAIN'S SEATSTo recline,pull up the recline control located below the inboard arm rest and lean back.To slide the seat of Dodge models,pull the slide control located on the left underside of the seat outward,and slidethe seat either forward or back. On C...

13 .

DAILY LIVINGDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 A-2CLOVERLEAF DINING TABLE (190 AND 200 MODELS)To use the "leaves":i) Pivot the table into the desired position.ii) In a seated position,with one hand under the table,push the su...

14 .

DAILY LIVINGDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 A-3SPARE TIRE STORAGE AND REMOVALFor vehicles not equipped with an optional "Continental" spare tire carrier,the spare tire is stored within thestorage area below the rear bed or...

15 .

REAR L-SHAPED LOUNGE TO DOUBLE BED (170-POPULAR AND 190-VERSATILE)To convert the lounge into a double bed:i) Remove cushion under TV cabinet and store.ii) Remove small rear back rest cushion on driver side and store.iii) Remove table top,rotate,place on le...

16 .

REAR DINETTE TO DOUBLE BED (190-VERSATILE)To convert the dinette into a double bed:i) Remove the table and legs from their bases and place the table on the lateral supports located on theupper edge of the seat base boxes.ii) Starting on the driver side,mov...

17 .

DAILY LIVINGDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 B-3FRONT LOUNGE SEATS (ALL MODELS)To convert the lounge seat into a single bed:i) For the driver side seat of Dodge models,swivel the driver captain's seat 270 degrees clockwise ...

18 .

APPLIANCE LOCATIONDAILY LIVINGDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 C-1APPLIANCE LOCATIONDAILY LIVINGDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 C-1

19 .

PRIVACY DOORS (170-POPULAR,190-POPULAR AND 200-POPULAR ) When privacy is required:i) Open the door on the suspended cupboard located in the bed area of your vehicle.ii) Release the plastic turn tab that secures the inner door,extend this door until privacy...

20 .

TOILETSee appropriate component Manufacturer's Owners Manual for operating instructions.STAND-UP AISLE SHOWERTo set up the stand-up aisle shower:i) If possible,park your vehicle sloping slightly to the rear to prevent water from running to the front of the...

21 .

WATER SYSTEMDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 E-1WATER SYSTEMYour vehicle is equipped with a water system for either completely,self contained,or fully dependent use. It is notequipped with a pressure regulator to compensate...

22 .

WASTE WATER STORAGE AND DUMPING SYSTEMYour vehicle is equipped with a waste water storage and dumping system that will provide adequate and effectivestorage and dumping of waste water. Your vehicle should be as level as possible to allow optimal operation ...

23 .

Waste Tank Flushing To flush the waste water tanks:i) Ensure that both tanks are empty.ii) Fill the black water tank by inserting a hose into the toilet and the grey water tank using the sink.iii) Dump both tanks.Both waste water tanks can be flushed using...

24 .

POTABLE WATER SYSTEM WINTERIZING To winterize your potable water system:i) Drain the entire system.ii) Add 2 L (1/2 gallon) of approved nontoxic recreational vehicle antifreeze to the fresh water tank usingthe gravity fill. Close water heater bypass valves...

25 .

ELECTRICAL SYSTEMDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 F-1Your vehicle's electrical system should not be subjected to changes and/or additions to circuitry,appliances,etc.without consulting your dealer for proper installation pr...

26 .

MONITOR PANELA monitor panel,located on the front closet partition above the passenger lounge seat,is provided to monitor theapproximate fluid levels in the fresh,grey and black water tanks,LP gas tank (Dodge models only),and charge levelin the auxiliary b...

27 .

AUTOMOTIVE BATTERYThe electronic radio in your vehicle will exert a small draw on the automotive battery to maintain the time andpreset stations. To prevent the battery from damage caused by being completely drained,the radio should bedisconnected from the...

28 .

L.P.GAS & SAFETY SYSTEMDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 G-1Your vehicle is equipped with an L.P.gas system which,when properly handled and maintained,will providetrouble and worry free operation of your L.P.gas fueled appli...

29 .

REFUELING PROCEDURESWARNING:Do not refuel L.P.gas tank to more than 80% of capacity.A properly refueled L.P.gas tank will contain approximately 80% of its volume as liquid L.P.gas. Over fueling of theL.P.gas tank can result in uncontrolled gas flow which c...

30 .

OWNER MAINTENANCEDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 H-1FIBERGLASS MAINTENANCE:To maintain the original appearance and finish,your vehicle's fiberglass running boards,roof and/or body must bewaxed at least annually.If deterior...

31 .

OWNER MAINTENANCEDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 H-2SPRING START UP:After storage,reactivate your vehicle for use by reversing all the procedures that you performed to prepare it forwinter storage.In addition,L.P.G.(liquid...

32 .

AT LEAST TWICE A YEAR:Check power steering fluid level.Check windshield washer level and wiper operation.Clean wiper blades with clean cloth dampened withwasher fluid.Check radiator,heater and air-conditioning hose for leaks or damage.Check for worn tires ...

33 .

LIMITED WARRANTY INFORMATIONDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 I-1DEFINITIONSHome & ParkHome & Park Motorhomes (A Division of HANMAR MOTOR CORPORATION)DealerDealer or any wholesale buyer of recreational vehicles,authorized...

34 .

AUTOMOTIVE WARRANTY - GENERAL MOTORS (CHEVROLET CHASSIS)The warranty currently offered by General Motors covers the manufacture of the Chevrolet chassis. The Purchaserwill receive the full time period and distance of the warr anty. In other words,the warra...

35 .

HOME & PARK MOTORHOMES LIMITED WARRANTYHome & Park warrants to the Purchaser that the vehicle is free from defects in material and workmanship on theportion manufactured by Home & Park,under normal use and service,for three (3) years,or 36,000 miles or 60,

36 .

LIMITED WARRANTY INFORMATIONThe following information must be provided when contacting the factory for warranty:Selling Home & Park Dealer:___________________________________________________________________Address:__________________________________________...

37 .

CUSTOMER ASSISTANCEDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 J-1POTENTIAL CUSTOMER REFERRAL PROGRAMIf you're like most Roadtrek owners,you will spend a lot of your valuable time giving tours of your Roadtrek tonumerous inquisitiv...

38 .

ADDRESS,PHONE & FACSIMILE NUMBERS,AND E-MAILAddress all inquiries to: Home & Park Motorhomes Warranty & Service Department100 Shirley AvenueKitchener,Ontario,Canada,N2B 2E1Telephone:toll free 888-ROADTREK (762-3873) or 519-745-1169Facsimile:519-745-1160e-m...

39 .

CUSTOMER SERVICE PROCEDURESDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 K-1OBTAINING MOTORHOME SERVICEThe solution to all your Roadtrek concerns starts with your Roadtrek DealerRoadtrek DealerThe dealership should always be given theop...

40 .

Doc No:FMSA0035 Rev:00Copyright(C) Hanmar Motor Corporation 203 L-1ROADTREK INTERNATIONAL CHAPTER FMCAA ROADTREK OWNERS' CLUBPLEASE PRINT MEMBERSHIP APPLICATION DATE ______________Last Name __________________ First Name ________________ Spouse __________...

41 .

CHANGE OF ADDRESS FORMDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 L-2

42 .

43 .

CUSTOMER REFERRAL CARDDoc No:MNSA0006 Rev:00Copyright(C) Hanmar Motor Corporation 203 L-4

44 .

Please contact Home & Park Motorhomes should you require additional customer referrral cards.

45 .

Doc No:MNSA0006 Issue Date:March 2003 Copyright(C) Hanmar Motor Corporation 2003 Printed In CanadaTM(R) "Home & Park" and "Roadtrek" are registered trademarks of J.J.Hanemaayer of which Hanmar Motor Corporation is a licensee and/ or registered userDivision...